ewheels EW-12 User Manual

Ewheels EW-12 User Manual

www.ewheelsdealers.com 

Feature Guide

Technical Specifications

**TURNING ON YOUR SCOOTER FOR THE 1ST TIME**

Before using your scooter for the first time, you must turn on the circuit breaker switch which is located underneath the seat. To access the circuit breaker, insert the key into the rear lock, and turn the key counter clockwise (left). You will hear the latch release, and you can now lift up the back of the seat to access the circuit breaker.

Operation of Scooter

  1. Battery Power Indicator The battery power indicator bars will light up when turned on. The battery indicator bars will only be displayed when the scooter is turned on. The bars represent the scooter’s current charge level.

  2. Emergency Brake TabThe emergency brake is located under the left side brake handle. The tab holds tension in the brake lines to keep the unit stationary while not in use. Activate by pulling the tab towards the handle while squeezing the left brake handle. The tab will travel towards the handle when the brake handle is approximately halfway. Squeeze the left brake handle to deactivate.

  3. Tiller Controls See below for all tiller functions labelled below. Status lights on the top of the tiller will illuminate or flash when the feature is activated.

Charging Instructions:

The smart charger included with your scooter will shut off its high current mode when the scooter is fully charged. When the light on the charger is red, the scooter is still charging. When the light turns green, this means the scooter is fully charged. Once fully charged, unplug within two hours to avoid overcharging.

The charging time varies depending on how charged the batteries are. If almost empty, the charge time may take up to 8 hours. If the red light stays on for more than 8 hours, unplug the charger. Do not exceed 8 hours charge time.

Batteries and Battery Maintenance:

Only use the recommend batteries for your scooter. Do not use lithium ion batteries. The batteries can be charged as needed without causing damage. You can wait until low, or charge right after a short ride. Avoid leaving on the charger for an extended period to avoid potential damage.

Specification of the battery that we recommend: Type: (4) 12 volt, 20 AH, Deep Cycle, Maintenance Free, Sealed Lead Acid

Note:– Do not use automotive starter batteries. They are not designed to handle long deep discharge and are unsafe for use in your scooter.– The useful life of a battery is quite often a reflection of the care it receives.– Always charge the batteries in a well-ventilated area.– The charger is intended for indoor use only.– Replace all batteries at the same time if weak.– Recharge the scooter at least once every month when not in use to avoid deterioration of the batteries.

Ramps and Curbs:

  1. Check that the ramp surface is roughened to prevent slipping. Never drive across a slope or turn sharply on a slope.
  2. When driving up curbs, always check the height of the curb to ensure that it does not exceed 4″ height.
  3. Always go forward up ramps and curbs.
  4. Avoid stopping completely when going over small objects or obstructions.

General:

  1. Always keep your feet on the scooter while riding.
  2. Do not exceed the weight capacity of 350 LBS.
  3. Do not attempt to lift or move the scooter by any of its removable parts. Personal injury and damage to the scooter may result.
  4. Never try to use your scooter beyond its limitations as described in the manual.
  5. Do not connect any electrical or mechanical device to the scooter. Failure to obey this instruction may result in injury and will void the warranty.
  6. Always comply with local laws and regulations.

Use While Under the Influence of Medication or Alcohol:

  1. Check with your physician if you are taking any medication that may affect your ability to operate your scooter safely.
  2. Do not operate your scooter while you are under the influence of alcohol as this may impair your ability to operate your scooter in a safe manner.

Safety Requirements:

Driving SurfaceThe EW-12 has the best stability and performs the best under the normal driving conditions (dry, level ground with concrete or asphalt). Extra care must be taken when riding on other surfaces (grass, gravel, etc.).

DO NOT exceed the specified climbing angle. Do not operate the scooter before you have fully read and understood the manual.

  • Always turn the scooter off before getting on or off the scooter.
  • Avoid driving in loose gravel, covered soil and sandstone.
  • Do not drive the scooter in unknown road conditions.
  • The scooter can ride over small obstacles within a certain height, but you must minimize the speed and slowly drive over the obstacle.
  • Do not operate the scooter under the influence of drugs or alcohol.
  • Do not park on steep slopes.
  • Changing the initial setting of refitting your scooter is forbidden.
  • Use caution when operating near busy streets, markets or shopping centres. Do not operate in unsafe areas.
  • Consult local authorities about the traffic rules for scooters in your city.
  • Hold the handlebar with both hands and put both feet on the floorboard while driving the scooter.
  • Never sit on the scooter in a moving vehicle.
  • Do not drive on uneven slopes or uneven ground; be careful when passing over slopes.
  • Never take the scooter on an escalator.
  • Do not operate on frozen, slippery or salty roads.
  • Never let the batteries freeze; do not charge when frozen.
  • Do not let the batteries every go completely dead. When low, do not let sit for an extended period or damage may occur.
  • Always use required safety equipment while operating.
  • Do not modify or change the electrical system and frame. Doing so will void the warranty.

Warranty- Recreational Scooters

Models IncludedEW-01, EW-02, EW-07, EW-08, EW-10, EW-11, EW,12, EW-14, EW-19, EW-20, EW-21, EW-29, EW- 32, EW- 36, EW-37, EW-38, EW-42, EW-44, EW-46, EW-52, EW-54, EW-66, EW-72, EW74, EW-77, EW-88, EW-REMO, EW-Vintage.

Three Year Limited WarrantyThree (3) years from the date of purchase on all structural frame components, seat post and frame.

One Year Limited WarrantyOne (1) Year from the date of purchase, if any part or electronic component of the scooter is found upon examination to be defective in material and/or workmanship, it will be replaced at Ewheels discretion.

Two Month WarrantyTwo (2) Months from the date of purchase on the batteries. Batteries are subject to a stringent wear and tear clause. Any battery faults due to a manufacturing defect will become obvious within the first two months of use. Any gradual deterioration in performance after this period is normal and associated with fair wear and tear, misuse or accidental damage and as such is not covered by the manufacturer’s warranty.

One Month WarrantyOne (1) Month from the date of purchase on the scooter’s charger.

WARRANTY EXCEPTIONS AND EXCLUSIONSService and Labour CostsUnless previously authorized, service calls and labour costs are NOT included or covered under any warranty. The purchaser is responsible for the delivery to the authorized repair facility. Satisfactory proof of purchase is always required for warranty service. Please contact Ewheels directly for any assistance in locating a service provider or to make a warranty claim.

Consumable ItemsConsumable items which may need replacing due to normal wear and tear like tires, tubes, lights, chains, upholstery and seating, brakes and brake pads, cables, fuses, buttons, shrouds and covers.

Damage, Accidental Damage and MisuseDamaged caused by: battery fluid spillage or leakage, abuse, misuse, accident, negligence, improper operation, excessive loading, maintenance, storage, acts of God, commercial use, or use other than normal, extreme riding, modifications and alterations.

Second Hand Owners and ResellingNo warranty will be offered or honoured for second hand owners. The warranty is exclusively offered to the original purchaser.

HOW TO MAKE A WARRANTY CLAIMInitiating A Warranty ClaimTo initiate a warranty claim, please contact Ewheels service department by calling 888- 5712845, or by email at “[email protected]“. Note that before any warranty claims will be fulfilled, satisfactory proof of purchase will be required, and a photo or video of the damaged part must be sent and reviewed by Ewheels.

Returning Faulty PartsDo not return faulty parts to Ewheels without prior consent. A request for a return authorization is required prior to returning items. All transportation costs and shipping damage incurred while submitting units and/or parts for repair or replacement are the responsibility of the original purchaser.

SHIPPING DAMAGE AND SHIPPING POLICIESShipping DamageIn the event shipping damage occurs, it must be reported and addressed in a timely manner. Shipping damage claims are time sensitive and cannot be delayed. In the event the packaging is extremely damaged and the bike is beyond repair, please refuse the shipment, and contact Ewheels for further steps.

Shipping ­ DomesticWhen applicable, part costs will be covered under warranty, and all warranty items will be shipped via FedEx Ground. Shipping fees will be at the expense of the purchaser.

Shipping ­ InternationalWhen applicable, parts will be provided under warranty at no charge, but shipping to any offshore and/or international location will be the responsibility of the original purchaser. International and offshore end-users must contact Ewheels directly to initiate the warranty process.

*Implied warranties, including those of merchantability and fitness for a particular purpose, are limited to one (1) year from the date of the original purchase and to the extent permitted by law. Any and all implied warranties are excluded. This is the exclusive remedy. Liabilities for consequential damages under any and all warranties are excluded*

Safety Manual

Intended UseYour scooter is a recreational scooter and is to be used for improving mobility in your daily activities such as walking. It is not a medical scooter or medical and does not and is not intended to provide medical benefits, medical assistance, medical therapy, or treat or alleviate any medical condition or disability.

Quick-Start WarningsThe below warnings and instructions caution against some activities. Reviewing this list is not a substitute for reading the entire Manual. Use common sense when operating your scooter.

  • Do not disassemble your scooter on your own.
  • Avoid touching hot parts of your scooter during or after operation.
  • Avoid touching hot parts of your scooter that may have become hot from exposure to sunlight.
  • Do not touch any chemicals in the scooter.
  • Keep your hands and other body parts away from moving parts of the scooter.
  • Do not operate the scooter with any loose clothing or dangling which wires which could become trapped in the wheels or other moving components of the scooter.
  • Do not use any battery which is not approved by Ewheels for use with your scooter.
  • Do not allow children to play on the scooter or use it without supervision.
  • Single-person scooters should only be used by one person at a time
  • Do not operate the scooter while under the influence of alcohol, drugs, or other medications which may impair your ability to operate a vehicle.
  • Do not operate the scooter while using a mobile phone or other mobile device.
  • Do not operate your scooter if it is not functioning properly.
  • Never try to operate your scooter beyond the its limitations as described in the manual.

Size and Weight LimitsYour scooter was designed to accommodate users up to a specified size and weight. As each scooter is designed and rated differently, ensure you check your particular scooter model’s limits. Periodically check your weight against your scooter’s limits, as your weight may fluctuate over time. Ensure other users of your scooter are within the weight limits. Operation of the scooter by a user over the weight limit can damage the scooter and can cause hazardous situations, including increased braking distances and times, decreased steering responsiveness, tip overs, and other dangers which may cause injury. Further, modifications which increase the riding height of the scooter, which raise the user’s riding height on the scooter, or which otherwise change the centre of gravity of the scooter can damage the scooter and cause the hazardous situations identified above. Ewheels is not responsible for damage to the scooter or personal injury caused by exceeding weight limitations or modifying the centre of gravity of your scooter. Do not adjust your seat while the scooter is in motion or operating.

General Operation —­ Safety BeltIf your scooter is equipped with a safety belt, use it all times when seated in the scooter. Do not operate your scooter without wearing the safety belt. Have the belt replaced by an authorized repair technician if the safety belt becomes frayed, cut, or shows other signs of wear or damage.

General Operation – MirrorsIf your scooter is equipped with mirrors, orient them so that you can see behind you. Orient the mirrors while sitting on the scooter but while the scooter is not moving and is not in operation. Never attempt to adjust the mirrors while operating the scooter. Proper orientation of the mirrors should allow you to see behind you and should minimize blind spots.

General Operation —­ Lights and SignalsIf your scooter is equipped with headlights and turn signals, use them. Using headlights at night, and even at day, increases your visibility to other vehicles. Using turn signals provides warning to vehicle and pedestrian traffic near you.

General Operation —­ Driving OutdoorsYour scooter is designed to be driven on clean, even, dry surfaces. Ewheels does not recommend you store your scooter outdoors. Your scooter is susceptible to damage to electronic, mechanical, or other components if exposed to water. If you are caught outside during inclement weather, seek shelter or ask someone for assistance.

Always ensure that the power is switched off when getting on or off the scooter. Never attempt to mount or dismount the scooter if it is operational or moving. Do not switch the power off when the scooter is still moving forward or in reverse. Always check that the variable speed switch is set to the desired speed setting. Always check that the desired direction of forward or reverse travel is selected when ready to drive.

General Operation — ­Public RoadsUnless specifically permitted or authorized by the state, do not drive your scooter on public roads. If you need to drive along a public road, use the sidewalk adjoining the road. Always use care when driving near to or around public roads, as you may be less visible to motor vehicles when riding the scooter because of your smaller relative size and slower relative speed. Always be aware of state and local rules of traffic, and take those rules into account when operating your scooter; it is your responsibility to know those rules, obey them, and understand how other traffic will operate in accordance with such rules. Ewheels recommends that you gain your first experiences with your scooter well away from public roads, so that you can learn and understand how the scooter operates and handles in a comfortable and quiet environment.

General Operation —­ Alternate SurfacesDo not drive your scooter onto stairs or escalators; serious injury will result. Do not attempt to drive your scooter onto stairs or escalators. Most elevators are safe for use with the scooter. When confronted with stairs or escalators, navigate to the closest elevator instead. Conduct a visual inspection and assess the quality and condition of the elevator before using it. Use care; some elevators have awkward entrance angles that can make ingress and egress difficult

General Operation —­ CurbsCurbs generally are formed in two manners: abrupt, vertical curbs and gradual, smooth curbs. Your scooter cannot drive over or off of an abrupt, vertical curb. Do not attempt to do so, as this will cause serious damage to your scooter and likely injury to yourself. Do not drive over a curb or object exceeding 4 inches in height. Your scooter can drive over most gradual, smooth curbs. Approach such curbs head-on, so that the scooter is oriented perpendicular to the curb. Consistently apply speed over the curb until the rear wheels of the scooter have moved just past the curb. Do not approach the curb at an oblique angle; doing so can increase the risk that your scooter tips over. Likewise, when moving down a curb, approach the curb perpendicular to it and not at an oblique angle. Avoid stopping completely when going over small objects, curbs, or other obstacles and obstructions.

General Operation —­ Incline ControlYour scooter can handle a wide range of inclines and declines. The scooter is safe for operation on most handicap accessible ramps. However, do not use the scooter on inclines of a degree which makes operation of the scooter difficult; if the scooter does not readily climb the incline, move off of the incline and/or ask for assistance. Likewise, do not use the scooter on declines of a degree which makes operation of the scooter difficult; if the scooter moves too quickly on an incline, fully apply the brakes, move off of the decline, and/or ask for assistance. Ewheels recommends that you only use ramps which have a roughened surface to prevent slipping. Never drive in a transverse direction across an incline or turn sharply on an incline. Never drive in a reverse direction down an incline. Because the capability of your scooter to climb an incline or descend a decline depends on a number of factors, such as the scooter’s specifications, your size and weight, the quality of the surface, and your personal setup of the scooter, eWheels does not guarantee the scooter’s safety on a specific angle of incline or decline. However, eWheels does not recommend you use your scooter on inclines or declines greater than 10 degrees, while making no guarantees of performance and safety on angles less than 10 degrees.

General Operation —­ CorneringAlways reduce your speed when making sharp turns. Always control your speed when cornering. As with any vehicle, manoeuvring a corner at a high speed increases the risk of tipping the scooter. You should manoeuvre at a speed which is reasonable for the scooter, its specifications and conditions, your size and weight, your angle of approach, the type of turn, and the surface conditions.

General Operation ­— InfluencesDo not operate the scooter while under the influence of alcohol, drugs, or other medications which may impair your ability to operate a vehicle. The scooter is heavy and can reach significant speeds, but even at low speeds it is dangerous to operate under the influence of alcohol, drugs, or other medications which may alter or impair your coordination, reaction time, reflexes, and other capabilities.

General Operation ­— Ingress and EgressExercise care when moving onto your scooter. Ensure the scooter is braked on level ground and the switch is in the off position. Brace yourself against a sturdy piece of furniture, or use a cane or other walking assistive equipment. Use your upper body to assist your legs in lowering you onto the scooter seat. Move downwardly slowly. Apply and buckle the safety belt. Sit for a few minutes before operating the scooter. Also exercise care when moving off of your scooter. Ensure the scooter is braked on level ground and the switch is in the off position. Unbuckle the safety belt. Getting up quickly or the wrong way could lead to injury. Look around for a sturdy piece of furniture, or use a cane or other walking assistive equipment. Use your upper body to assist your legs in lifting you. Lift slowly and pause for a few moments if you feel unsteady. Stand for a few minutes before moving further.

Regular MaintenanceAlways check your scooter for normal operation, loose parts, and defects before operating. If you find a problem, have it repaired before operating.

Keep your scooter clean and dry. Do not use a high-pressure water sprayer to clean the scooter. If you wash your scooter, use a damp sponge or cloth, and dry the scooter thoroughly before operating. Do not immerse any components in water.

Always check your scooter for wear or damage to the tires before operating.

Keep tires inflated to their recommended tire pressure at all times. Regularly check tires for wear, cracks, nails, or other damage. Keep tires clean and replace them when damaged. Failure to maintain the tires at the recommended tire pressure will cause premature wear, and failure to maintain the tires could lead to damage or personal injury.

Use Within a Motor VehicleDo not sit in or operate your scooter in a motor vehicle such as a train, bus, or large van. Stow or rack your scooter according to the motor vehicle’s guidelines before entering or when entering the motor vehicle. Never sit in your scooter while it is on or in a motor vehicle which is operating or in motion.

BatteriesDo not use automotive batteries with your scooter. Always charge your scooter’s batteries in a well-ventilated area. eWheels recommends that you periodically charge your batteries, such as once a month, when your scooter is not in regular use. Ensure the switch is in the off position when the batteries are charged. Ensure that the power plug is inserted and plugged firmly into the battery during charging. Do not use an extension cord while charging the batteries. Do not use a battery which is cracked, leaking, or otherwise damaged. Do not use your scooter if the battery is cracked, leaking, or otherwise damaged. Keep tools and other metal elements away from the contact terminals of the batteries. Remove the batteries when transporting your scooter.

report this ad

Modifications to the ScooterDo not disassemble or modify your scooter on your own. Do not remove or disable any element or feature of your scooter. Do not modify the programmable controller governing the scooter’s electric, electronic, and electromechanical operations. While there are a wide range of after-market products available to modify and alter scooters, some may make your scooter more dangerous to operate or may impair your ability to operate the scooter safely. eWheels makes no claim or warranty as to the safety, effectiveness, and operability of any aftermarket product added to your scooter, or as to any modification you make or have made to your scooter, which are not performed by eWheels or eWheels approved vendors. eWheels is not responsible for damage to the scooter or personal injury caused by disassembly, modification, or other alteration of your scooter.

References

[xyz-ips snippet=”download-snippet”]

Posted

in

by

admin

Tags:

, ,