Nilfisk Instruction Manual

Nilfisk Instruction

D 140.4, D-PG 140.4, E 145.4 , E 150.2, E 160.1

Safety Instructions

Before first use of the machine, read the instructions carefully. Save instructions for later use.

Safety instructions marked with this symbol must be observed to prevent personal injury or serious damage to property.

WARNING:

  • This machine has been designed for use with cleaning agents supplied or recommended by Nilfisk. The use of other cleaning agents or chemicals may adversely affect the safety of the machine.
  • High pressure jets can be dangerous if subject to misuse. The jet must not be direct-ed at persons, live electrical equipment or the machine itself.
  • Do not use the machine within range of persons unless they wear protective clothes.
  • Do not direct the jet against yourself or others in order to clean footwear.
  • Risk of explosion – Do not spray flammable liquids. High pressure washers shall not be used by children or untrained personnel.
  • High pressure hoses, fittings and couplings are important for the safety of the machine. Use only hoses, fittings and couplings recommended by Nilfisk.
  • To ensure machine safety, use only original spare parts recommended by Nilfisk.
  • Water that has flown through back-flow preventers is considered to be non-potable.
  • Don’t use the machine if a supply cord or important parts of the machine are damaged, e.g. safety devices, high pressure hoses, trigger gun.
  • Inadequate extension cords can be dangerous. If an extension cord is used, it shall be suitable for outdoor use, and the connection has to be kept dry and off the ground. It is recommended that this is accomplished by a cord reel which keeps the sock-et at least 60 mm above the ground.
  • Switch off and unplug the machine when leaving it unattended, when finished using it or when con-verting it to another function, when doing repair and maintenance.
  • During use of high pressure washers, aerosols may be formed. Inhalation of aerosols can be haz-ardous to health, for the protection against aerosols a respiratory mask of class FFP 2 or equivalent may be needed, depending on the cleaning environment.
Intended Use and Terms of Liability
  • The C-, D-, E- and P-series have been developed for domestic cleaning pur poses only and for use in an upright position. Any other use is considered as improper use.
  • A high pressure washer operates with different levels of pressure and cleaning detergents for various cleaning tasks and results. Always follow instructions on detergents for use, emergency and disposal.
  • Do not operate the machine at temperatures be-low 0°C. Never start a frozen machine, never use it indoor and never cover it during use. This is considered improper and wrongful use. Use of wrongful pressure, detergent and/or applications may cause damage to machine, surfaces, material and devices.
  • All of the above is considered improper and wrongful use. Nilfisk accepts no liability for any damage resulting from any improper or wrongful use.
  • Please refer to our website at www.get-started.nilfisk.com for further instructions and information on use, emergency and disposal.

Safety devices and their functioning

The machine automatically stops when releasing the trigger. The machine will start again when re-activating the trigger. The spray handle features a locking device. When activated, the spray handle cannot be operated.The machine has an automatic self-resetting thermal protector. If the machine is overheated, the thermal protector will cut the power supply. In this case, wait for the machine to cool down. An integrated hydrau-lic safety valve protects the system from excessive pressure.

Precautions

The electric supply connection shall be made by a qualified electrician and comply with IEC 60364-1. It is recommended that the electric supply to this machine should include either a residual current device that will interrupt the supply if the leakage current to earth exceeds 30 mA for 30 ms or a device that will prove earth circuit.

  • Use motor start/delayed fuses with characteristic D according to IEC 947-2 or corresponding standards outside IEC.
  • If the supply cord is damaged, it must be replaced by an authorized Nilfisk distributor or similar qualified person in order to avoid a hazard.
  • No actions needed for adjusting machines marked with dual voltage and frequency.
  • Supervise children not to play with the machine.
  • The operator and any one in the immediate vicinity of the site for cleaning should take action to pro-tect oneself from being struck by debris dislodged during operation.
  • Always wear safety boots, respiratory mask, ear protection, goggles and protective clothing during operation.
  • The high pressure generated by the machine is a particular source of danger. Hold the spray lance firmly with both hands. The spray lance is affected by a kickback force and a sudden torque during operation.
  • See PART 3:3 for the actual size of the kickback force.
  • During transportation: Position the machine horizontally on the backside and secure with straps.

Within EU

  • High pressure washers shall not be used nor maintained by children. The machine can be used by people with reduced physical, sensory or mental capabilities or lack of experience and knowledge if given supervision or instructions concerning use of the machine in a safe way and understands the hazards involved.

Outside EU 

  • High pressure washers shall not be used nor maintained by children or untrained people or people with reduced physical, sensory or mental capabilities or lack of experience and knowledge.

User Guide

Provides a general overview of the machine and operation elements along with illustrated sections on preparation, operation, water connection, storage, and user maintenance.

Unpacking and preparing for use: Follow illustrations in A.

Connection to potable water mains: High pressure washers are not suitable for con-nection to the potable water mains. Always check national regulations before connecting the machine to potable water mains and use a back-flow preventer if required.

  • Use ½” garden hose, 10-25 m.
  • Follow illustrations in B.

Connection to other water sources: You can connect the machine to e.g. rain water vessels, rivers, lakes and cisterns etc. and operate it in suction mode. Follow illustrations in C.

Pairing of spray handle and machine: C-PG and D-PG series only. After battery insert, D1.1, you have 2 min. to pair spray handle and machine. The light will flash orange when searching for the machine. When paired, the light will turn off. Follow illustrations D1.1 to D1.5. If pairing aborts, do pairing according to illustrations D2.1 to D2.5. Power regulation is indicated by green light, see illustrationD3.1 and D3.2.

Leaving the machine unattended > 5 min: See listed warnings. Follow the illustrations in E.

After use and storage: After use always: Turn off the machine. Empty ma-chine and accessories of water to avoid frost damage. Remove the plug from socket. Disconnect water inlet hose. Wind up electrical cable and high pressure hose to avoid damage of cable, high pressure hose and fittings. Storage of machine shall be frost free.

Maintenance, inspection and repair: Maintenance of the machine should always be done when starting up after long time of storage.

  • Before use, always inspect the machine and equipment for damages. In case of damages, act according to listed warnings.
  • Do not attempt any maintenance not described in the instructions. If the machine refuses to start, stops, pulsates, pressure fluctuates, motor buzzes, fuse blows or no water comes out, check the trouble shooting diagram at our website www.get-started. nilfisk.com. Any repair should always be made in Nilfisk authorized workshop with original Nilfisk spare parts.
  • User maintenance according to illustrations in G.
Diagrams

Technical Data and Declaration of Conformity

    D 140.4

D-PG 140.4

 E 145.4 E 150.2 E 160.1
Electric specifications Unom 230-240 V
fnom 50 Hz
Pnom 2.4 kW 2.1 kW 2.3 kW
Inom 10 A 9.5 A 10 A 10.5 A
Protection Class Class I/Class

II

 Class I
Protection degree IP XX IP X5
Hydraulic specifications pnom 13.5 MPa / 135 bar 13.0 MPa / 130 bar 14.0 MPa / 140 bar 14.5 MPa / 145 bar
pmax 14.0 MPa / 140 bar 14.5 MPa / 145 bar 15.0 MPa / 150 bar 16.0 MPa / 160 bar
Q 7.0 l/min / 420 l/h 7.0 l/min / 420 l/h 6.7 l/min / 400 l/h 6.8 l/min / 410 l/h
Qmax 8.3 l/min / 500 l/h
Max. water inlet pressure pinlet max 1 Mpa / 10 bar
Max water inlet temperature tinlet max 40° C
Max water inlet temp. suction mode tinlet max 20° C
Kick-back force Fkickback 19.2 N 19.2 N 18.4 N 19.3 N
Weight Mmachine 13.8 kg 18.6 kg 19.8 kg 20.6 kg
Hand-arm vibration according to: Standard nozzle aha < 2.5 ± 1 m/s2
Sound pressure level LpA LpAstandard 77.2 ± 2 dB(A) 71.8 ± 2 dB(A)
Guaranteed sound power level LWA LwAstandard 92 dB(A) 86 dB(A)

We, Nilfisk hereby declare under our sole responsibility, that the above mentioned product(s) is/are in conformity with the following directives and standards

HEAD QUARTER

DENMARKNilfisk A/SKornmarksvej 1DK-2605 BroendbyTel.: (+45) 4323 8100Website: www.nilfisk.com

SALES COMPANIES ARGENTINANilfisk srl.Edificio Central ParkHerrera 1855, 6th floor/604Ciudad de Buenos AiresTel.: (+54) 11 6091 1571Website: www.consumer.nilfisk.com.ar

AUSTRALIANilfisk Pty LtdUnit 1/13 Bessemer Street Blacktown NSW 2148Tel.: (+61) 2 98348100Website: www.consumer.nilfisk.com.au

AUSTRIANilfisk GmbHMetzgerstrasse 685101 Bergheim bei SalzburgTel.: (+43) 662 456 400 90Website: www.nilfisk.at

BELGIUMNilfisk n.v-s.a.Riverside Business ParkBoulevard Internationalelaan 55 Bâtiment C3/C4 GebouwBruxelles 1070Tel.: (+32) 24 67 60 50Website: www.consumer.nilfisk.be

BRAZILNilfisk do BrasilAv. Eng. Luis Carlos Berrini, 55040 Andar, Sala 03SP – 04571-000 Sao PauloTel.: (+11) 3959-0300 / 3945-4744Website: www.nilfisk.com.br

CANADANilfisk Canada Company240 Superior Boulevard Mississauga, Ontario L5T 2L2Tel.: (+1) 800-668-8400Website: www.nilfisk.ca

CHILENilfisk S.A. (Comercial KCS Ltda) Salar de Llamara 8228320000 SantiagoTel.: (+56) 2684 5000Website: www.nilfisk.cl

CHINANilfisk4189 Yindu RoadXinzhuang Industrial Park201108 ShanghaiTel.: (+86) 21 3323 2000Website: www.nilfisk.cn

CZECH REPUBLICNilfisk s.r.o.VGP Park Horní PočerniceDo Čertous 1/2658193 00 Praha 9Tel.: (+420) 244 090 912Website: www.consumer.nilfisk.cz

DENMARKNilfisk Danmark A/SIndustrivej 1Hadsund, DK-9560Tel.: 72 18 21 20Website: www.consumer.nilfisk.dk

FINLANDNilfisk Oy AbKoskelontie 23 E02920 EspooTel.: (+358) 207 890 600Website: www.consumer.nilfisk.fi

FRANCENilfisk SAS26 Avenue de la BaltiqueVillebon sur Yvette91978 Courtaboeuf CedexTel.: (+33) 169 59 87 24Website: www.consumer.nilfisk.fr

GERMANYNilfisk GmbHGuido-Oberdorfer-Straße 2-10 89287 BellenbergTel.: (+49) (0)7306/72-444Website: www.consumer.nilfisk.de

GREECENilfisk A.E.Αναπαύσεως 29Κορωπί Τ.Κ. 194 00Tel.: (30) 210 9119 600Website: www.consumer.nilfisk.gr

HOLLANDNilfisk B.V.Versterkerstraat 51322 AN AlmereTel.: (+31) 036 5460760Website: www.consumer.nilfisk.nl

HONG KONGNilfisk Ltd.2001 HK Worsted MillsIndustrial Building31-39, Wo Tong Tsui St.Kwai Chung, N.T.Tel.: (+852) 2427 5951Website: www.nilfisk.com

HUNGARYNilfisk Kft.II. Rákóczi Ferenc út 102310 Szigetszentmiklós-LakihegyTel.: (+36) 24 475 550Website: www.nilfisk.hu

INDIANilfisk India LimitedPramukh Plaza, ‘B’ Wing, 4th floor, Unit No. 403 Cardinal Gracious Road, ChakalaAndheri (East) Mumbai 400 099Tel.: (+91) 22 6118 8188Website: www.nilfisk.in

IRELANDNilfisk1 Stokes PlaceSt. Stephen’s GreenDublin 2Tel.: (+35) 3 12 94 38 38Website: www.nilfisk.ie

ITALYNilfisk SpAStrada Comunale della Braglia, 1826862 Guardamiglio (LO)Tel.: (+39) (0) 377 414021Website: www.nilfisk.it

JAPANNilfisk Inc.1-6-6 Kita-shinyokohama, Kouhoku-ku Yokohama, 223-0059Tel.: (+81) 45548 2571Website: www.nilfisk.com

MALAYSIANilfisk Sdn BhdSd 33, Jalan KIP 10Taman Perindustrian KIPSri Damansara52200 Kuala LumpurTel.: +603 6275 3120Website: www.nilfisk.com

MÉXICONilfisk de México S. de R.L. de C.V.Pirineos 515, Int. 60-70Zona Industrial Benito JuárezQueretaro, QRO, CP 76120Tel.: (+52) (442) 427 77 91Website: www.nilfisk.com

NEW ZEALANDNilfisk LimitedSuite F, Building E42 Tawa Drive0632 Albany AucklandTel.: (+64) 9 414 1996Website: www.nilfisk.com

NORWAYNilfisk ASBjørnerudveien 241266 OsloTel.: (+47) 22 75 17 80Website: www.consumer.nilfisk.no

PERUNilfisk S.A.C.Calle Boulevard 162, Of. 703, Lima 33- Perú LimaTel.: (511) 435-6840Website: www.nilfisk.com

POLANDNilfisk Sp. Z.O.O.Millenium Logistic Parkul. 3 Maja 8, Bud. B405-800 PruszkówTel.: (+48) 22 738 3750Website: www.consumer.nilfisk.pl

PORTUGALNilfisk Lda.Sintra Business ParkZona Industrial Da AbrunheiraEdificio 1, 1° AP2710-089 SintraTel.: (+351) 21 911 2670Website: www.nilfisk.pt

References

[xyz-ips snippet=”download-snippet”]

Posted

in

by

admin

Tags:

, , , , ,