Refrigerated GN CounterInstruction manual
ModelDA546/DA547/DA548/DA549
Safety Tips
- Position on a flat, stable surface.
- A service agent/qualified technician should carry out installation and any repairs if required. Do not remove any components or service panels on this product.• Consult Local and National Standards to comply with the following:• Health and Safety at Work Legislation• BS EN Codes of Practice• Fire Precautions• IEE Wiring Regulations• Building Regulations
- DO NOT use jet/pressure washers to clean the appliance.
- DO NOT use the appliance outside.
- DO NOT use this appliance to store medical supplies.
- DO NOT stand or support yourself on the base, drawers, or doors.
- DO NOT allow oil or fat to come into contact with the plastic components or door seal. Clean immediately if contact occurs.
- Always carry, store and handle the appliance in a vertical position and move by holding the base of the appliance.
- Always switch off and disconnect the power supply to the unit before cleaning.
- Keep all packaging away from children. Dispose of the packaging in accordance with the regulations of local authorities.
- If the power cord is damaged, it must be replaced by a POLAR agent or a recommended qualified technician in order to avoid a hazard.
- This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience or knowledge unless they have been given supervision or instruction concerning the use of the appliance by a person responsible for their safety.
- POLAR recommends that this appliance should be periodically tested (at least annually) by a Competent Person. Testing should include, but not be limited to Visual Inspection, Polarity Test, Earth Continuity, Insulation Continuity, and Functional Testing.
- POLAR recommends that this product be connected to a circuit protected by an appropriate RCD (Residual Current Device).
Caution Risk of Fire
- Do not store explosive substances such as aerosol cans with a flammable propellant in this appliance.
- Warning: Keep all ventilation openings clear of obstruction. The unit should not be boxed in without adequate ventilation.
- Warning: Do not use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer.
- Warning: Do not damage the refrigerant circuit.
- Warning: Do not use electrical appliances inside the food storage compartments of the appliance, unless they are the type recommended by the manufacturer.
Product Description
- DA546 – Ventilated Refrigerated GN counter with 2 drawers
- DA547 – Ventilated Refrigerated GN counter with 4 drawers
- DA548 – Ventilated Refrigerated GN counter with 6 drawers
- DA549 – Ventilated Refrigerated GN counter with 8 drawers
Introduction
Please take a few moments to carefully read through this manual. Correct maintenance and operation of this machine will provide the best possible performance from your POLAR product.
Pack Contents
The following is included:
- POLAR Refrigerator
- Instruction manual
- Spacer (x2)
POLAR prides itself on quality and service, ensuring that at the time of packaging the contents are supplied fully functional and free of damage.Should you find any damage as a result of transit, please contact your POLAR dealer immediately.
Installation
Note: If the unit has not been stored or moved in an upright position, let it stand upright for approximately 12 hours before the operation. If in doubt allow standing.
- Remove the appliance from the packaging.Make sure that all protective plastic film and coatings are thoroughly removed from all surfaces.
- Maintain a distance of 20cm (7 inches) between the unit and walls or other objects for ventilation. NEVER LOCATE NEXT TO OR NEAR A HEAT SOURCE.
To avoid being pushed tight against the wall accidentally and ensure good ventilation, 2 spaces are supplied for mounting on the rear.Note: Before using the appliance for the first time, clean the interior with soapy water. - Set the brakes on the castors to keep the appliance in position.
Operation
Storing FoodTo get the best results from your POLAR appliance, follow these instructions:
- Only store foodstuffs in the appliance when it has reached the correct operating temperature.
- Do not place uncovered hot food or liquid inside the appliance.
- Wrap or cover food where possible.
- Do not obstruct the fans inside the appliance.
- Avoid opening the doors for prolonged periods of time.
Turn On
- Ensure the power switch is set to [O] and turn on at the socket.
- Switch on the Power [I]. The current temperature within the appliance is displayed.
Control Panel
Set the Operating Temperature
- Hold the SET button for 3 seconds. The value of the current setpoint will be displayed.
- Press the or buttons to display the required temperature.
- Press the SET button to store the temperature.
Manual Defrost
- The appliance will automatically run a defrost cycle every six hours.
- To manually defrost the appliance: Press and hold the defrost button “aux” for 2 seconds to begin a manual defrost. The defrost light illuminates.
Cleaning, Care & Maintenance
Defrost appliance at least every 3 months, more often if required.Switch off and disconnect from the power supply before cleaning.
- Clean the interior of the appliance as often as possible.
- Do not use abrasive cleaning agents. These can leave harmful residues.
- Clean the door seal with warm soapy water.
- Always wipe dry after cleaning.
- Do not allow water used in cleaning to run through the drain hole into the evaporation pan.
- Take care when cleaning the rear of the appliance. Sharp edges can be cut.
- A POLAR agent or qualified technician must carry out repairs if required.
Stainless Steel CareTo maintain the stainless steel exterior of your Polar item, please consider the following information:Never:
- Use abrasive Scourers or scrubbing pads, etc.
- Use Chlorinated or acidic detergents
- Allow anything e.g. food, dirt, cleaning chemicals to remain on the surface for longer than necessary, clean them off right away.
- Allow the surface to remain wet.
Do:
- Clean often.
- Use soft Cloths or plastic Scourers.
- Rub with the grain of the metal, rather than across it.
- Use detergents and polish designed for cleaning Stainless Steel.
- Ensure that the cleaning products are washed off fully and that the steel is left dry.
Routine MaintenanceCondenser Cleaning
- The condenser is part of the refrigeration system. The condenser requires monthly cleaning.
- Always disconnect the power supply before carrying out Routine Maintenance.
- Failure to clean the condenser will reduce the performance and life of your Polar unit and may invalidate your warranty.
- These models have a removable filter that can be cleaned with a vacuum cleaner.
Troubleshooting
If your POLAR appliance develops a fault, please check the following table before making a call to the Helpline or your POLAR dealer.
| Fault | Probable Cause | Solution |
| The appliance is not working | The unit is not switched on | Check the unit is plugged in correctly and switched on |
| Plug and lead are damaged | Call POLAR agent or qualified Technician | |
| Fuse in the plug has blown | Replace the fuse | |
| Power supply | Check power supply | |
| The appliance turns on, but the temperature is too high/low | Too much ice on the evaporator | Defrost the appliance |
| Condenser blocked with dust | Clean the Condenser | |
| Doors are not shut properly | Check doors are shut and seals are not damaged | |
| The appliance is located near a heat source or airflow to the condenser is being interrupted | Move the refrigerator to a more suitable location | |
| Ambient temperature is too high | Increase ventilation or move the appliance to a cooler position | |
| Unsuitable foodstuffs are being stored in the appliance | Remove any excessive hot foodstuffs or blockages to the fan | |
| Appliance is overloaded | Reduce the amount of food stored in the appliance | |
| The appliance is leaking water | The appliance is not properly leveled | Adjust the screw feet to level the appliance (if applicable) |
| The discharge outlet is blocked | Clear the discharge outlet | |
| The movement of water to the drain is obstructed | Clear the floor of the appliance (if applicable) | |
| The water container is damaged | Call POLAR agent or qualified Technician | |
| The drip tray is overflowing | Empty the drip tray (if applicable) | |
| The appliance is unusually loud | Loose nut/screw | Check and tighten all nuts and screws |
| The appliance has not been installed in a level or stable position | Check installation position and change if necessary |
Technical Specifications
| Nodal | Voltage | Power | Current | Temperature Range | Capacity (Litres) | Refrigerant | Dimensions H×WaDmm | Weight (kg) |
| DA546 | 230V 5014 | 300W | 1.8A | -2°C – 8°C | 59 | R600a 959 | 860 x 925 x 700 | 69 |
| DAS47 | 230V 5014 | 300W | 1.8A | -2°C – 8°C | 118 | R600a 95g | 860 x 1360 x 700 | 118 |
| DA548 | 230V 5014 | 300W | 1.8A | -2°C – 8°C | 230 | R600a 95g | 860 x 1795 x 700 | 164 |
| DA549 | BOY 50Hz | 300W | 1.8A | -2°C – 8°C | 366 | R600a 95g | 860 x 2230 x 700 | 193 |
Electrical Wiring
POLAR appliances are supplied with a 3 pin BS1363 plug and lead.The plug is to be connected to a suitable mains socket.POLAR appliances are wired as follows:
- Live wire (coloured brown) to terminal marked L
- Neutral wire (coloured blue) to terminal marked N
- Earth wire (coloured green/yellow) to terminal marked E
This appliance must be earthed.If in doubt consult a qualified electrician.Electrical isolation points must be kept clear of any obstructions. In the event of any emergency disconnection being required, they must be readily accessible.
Disposal
EU regulations require refrigeration products to be disposed of by specialist companies who remove or recycle all gasses, metal, and plastic components.Consult your local waste collection authority regarding the disposal of your appliance. Local authorities are not obliged to dispose of commercial refrigeration equipment but may be able to offer advice on how to dispose of the equipment locally.Alternatively, call the POLAR helpline for details of national disposal companies within the EU.
Compliance
The WEEE logo on this product or its documentation indicates that the product must not be disposed of as household waste. To help prevent possible harm to human health and/or the environment, the product must be disposed of in an approved and environmentally safe recycling process. For further information on how to dispose of this product correctly, contact the product supplier, or the local authority responsible for waste disposal in your area.POLAR parts have undergone strict product testing in order to comply with regulatory standards and specifications set by international, independent,and federal authorities.POLAR products have been approved to carry the following symbol:All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, without the prior written permission of POLAR.Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserves the right to change specifications without notice.
DECLARATION OF CONFORMITY
Conformiteitsverklaring
|
Equipment Type |
Model |
|
| U-Series Refrigerated GN counter with 2 drawersU-Series Refrigerated GN counter with 4 drawersU-Series Refrigerated GN counter with 6 drawersU-Series Refrigerated GN counter with 8 drawers | DA546 (& -E)DA547 (& -E)DA548 (& -E)DA549 (& -E) | |
| Application of Territory Legislation & Council Directives(s) | Machinery Directive 2006/42/ECEN 60335-1:2012 +A11:2014 +A13:2017EN 60335-2-89:2010 +A1:2016 +A2:2017EN 62233:2008Electro-Magnetic Compatibility (EMC) Directive 2014/30/EU – recast of 2004/108/ECEN 55014-1:2017EN 55014-2:2015EN 61000-3-2: 2014EN 61000-3-3: 2013Restriction of Hazardous Substances Directive (RoHS) 2015/863 amending Annex II to Directive 2011/65/EU | |
|
Producer Name |
Polar |
|
| I, the undersigned, hereby declare that the equipment specified above conforms to the above Territory Legislation, Directive(s), and Standard(s). | ||
| Date | 11th January 2021 | |
| Signature | |
 |
| Full Name | Ashley Hooper | Eoghan Donnellan |
| Position | Technical & Quality Manager | Commercial Manager/ Importer |
| Producer Address | Fourth Way, Avonmouth, Bristol, BS11 8TB United Kingdom | 42 North Point Business Park New Mallow Road CorkIreland |
report this ad
| UK | +44 (0)845 146 2887 |
| Eire | |
| NL | 040 — 2628080 |
| FR | 01 60 34 28 80 |
| BE-NL | 0800-29129 |
| BE-FR | 0800-29229 |
| DE | 0800 — 1860806 |
| IT | N/A |
| ES | 901-100 133 |
| PT | [email protected] |
http://www.polar-refrigerator.com/DA546-DA549_ML_A5_v3_20210126
http://www.polar-refrigerator.com/DA546-DA549_ML_A5_v3_20210126.indb 482021/1/26 11:49
References
[xyz-ips snippet=”download-snippet”]